Winter agricultural vehicles start smartly

In winter, when the temperature drops, agricultural vehicles will encounter difficulties in starting, and some will not be able to start normally. Instead, they have to use hot water, open flames, and push-pulls and other auxiliary measures. It takes a long time before they can barely start. At that time, it also accelerated the damage of vehicle parts and could easily cause unsafe accidents, which seriously affected the operational efficiency of vehicles. Causes of difficult starting are many reasons, mainly: poor engine operating conditions, frozen fuel oil, increased viscosity of lubrication oil, preheating device damage, and electrical starting device failure in five aspects. Taking appropriate measures to deal with it, the problem of difficult start will be solved. 1, do a good job in seasonal maintenance on the basis of vehicle maintenance, focus on doing a good job engine maintenance, testing and testing of various systems and pumps, fuel injectors, cylinders, pistons, intake and exhaust valves and other components, a serious wear and tear Repairs or replacements are made, and fuel supply advance angle, valve timing, valve clearance, etc. are strictly adjusted to the standard state. Through maintenance, maintain the good performance of the engine. 2, timely replacement of fuel to prevent fuel freezing I commonly used 0 # and -10 # diesel, the freezing point is 0 °C and -10 °C. Under normal circumstances, -10# diesel oil should be replaced from mid-November to the end of February of the following year. 3, the use of high-grade lubrication oil cold start resistance in winter is mainly from the sticky oil, starting power can not overcome this resistance, so that the engine reaches the starting speed and start. At present, major oil refineries produce advanced oils, which include many effective ingredients such as friction reducing agents. Compared with common bulk oils, they have good low-temperature fluidity, small starting resistance, and good lubricating effect, which can extend the service life of components. Although the price is twice as expensive, it is a good deal. 4. Recovery of preheating devices Multi-cylinder engines equipped with agricultural vehicles are generally equipped with a preheating starter. The principle of preheating start is: After powering on the glow plug for a few seconds, it warms up and becomes hot. The motor drives the engine. The fuel injected into the cylinder is heated, rapidly gasifies and expands, generates a momentary thrust to the piston, and accelerates the rotation of the engine. Play a "burst" that is the effect. Some vehicle preheating devices were not repaired after being damaged, and some vehicles were removed from the preheating line when they were overhauled. In the winter, they must be resumed and the starting effect is very good. 5, regular maintenance of electric starting device, to provide enough power for the cold start of the engine at any time to observe the instrument, to maintain normal battery charging; tighten the battery and other line connector, keep the circuit in good contact; regular maintenance of the motor, to maintain good motor performance. Grasp the above five aspects, the use of vehicles in the winter, you can do a shake immediately, the motor is a dozen, no longer have to worry about starting trouble.

Mingtai camera Operating Lamp HD recording system is installed on the original Surgical Light basis, camera install on the LED light plate, video host install on the support, the whole recording system based on 1080P high quality picture, recording documents save on the local hard drive, can be edited, camera and video host connect by wire, connector use good quality BNC connector, not attenuating and interfering signal, convenient for site assembly.

For more information about Operating Light, Operating Table, Hospital Bed and Medical Pendant please visit website.

Camera Operation Light

Camera Operation Light,Mobile Operating Light,Operating Light With Camera,Led Medical Operation Light

Shandong Mingtai Medical Equipment Group Co., Ltd , http://www.mingtaic.com